Mini Mobile Low Cost Maize Corn Rice Grains Drying Machine Small Grain Dryer Paddy
Introduction:
This machine is portable,mini type. It's suitable for drying a lot of kinds of grains. Such as corns, rice, beans, wheat,etc. It's easy to operate. High efficient.Dry the species with a hot wind of no more than 60 degrees.The whole process is under automatic control, no manual management is needed, the flow cycle is dry, the mixed seeds are dry and the humidity is consistent, and the seeds are not burned or polluted.
Feature:
1.Take hot air as the drying medium, adopt the cycle drying process, the material is evenly heated and fully dehydrated, and the quality after drying is good;
2.equipped with automatic online temperature measurement, humidity measurement device.
3.automatic shutdown, simple operation, greatly reduce labor costs.
4.At the same time at dry can also achieve the purpose of sterilization and deodorization.
5.Wide application range and good drying uniformity.
Parameter:
| Model |
SH-1T |
SH-2T |
SH-4T |
SH-6T |
| Silo Volume |
1.5m³ |
3.8m³ |
6.5m³ |
9.6m³ |
| Dry type |
Low temperature hot air cycle dry |
| Air temperature range |
Paddy:45-60℃;Corn:100-130℃;Wheat:90-110℃ |
| Transport height |
2.1m |
2.7m |
2.9m |
2.9m |
|
| Operation height |
2.1m |
3.46m |
3.85m |
4.92m |
|
| Area |
8m2 |
13m2 |
15.5m2 |
16.3m2 |
|
| Coal and wood Oven |
Clean oven,Ignition by manual
(If use other fuel,need different design)
|
| Fuel consumption |
Coal |
(Standard conditions)18kg/t |
| |
Gas |
(Standard conditions)7m³/t |
| |
Diesel oil |
(Standard conditions)7.5L/t |
| Total power |
3kw |
8.5kw |
13.13kw |
19.4kw |
|
|
Capacity:
|
1T/batch |
2T/batchh |
4T/batch |
6T/batch |
|
| |
Note:Each batch need 2-3h |
| Precipitation rate (%/h) |
Paddy:1.7-2.5℃;Corn:3.8-6;Wheat:2.8-4.5℃ |
| Safety Devices |
Thermal relay,Error alarm, Times Switch, Overheat alam |
| Daily production is calculated by the condition from25% to 14% moisture. |
Main Characteristics
1. Split structure is adopted for the entire machine, which facilitates transportation and installation;
2. Low installed capacity: The installed capacity for the whole unit totals 13kw only;
3. Low consumption of electricity and coal and low cost: The device dries wheat of 1.5tons/hr, consumes coal of 20kg and electricity of 5-7Kw/h in standard condition;
4. Large range of moisture reduction: It can reduce the wet grain of any moisture to the safe moisture level on a one-time basis and is most suitable for drying grain of humidity below 30%;
5. Free of pollution: The coal-fired hot blast furnace will heat fresh air as drying medium by exchanger. In this way, the dried grain will be free of pollution.
6. Small floor area: The entire unit covers a floor space of 15 square meters.
8. Automatic control: This equipment employs electric control and carries out automatic control on hot air temperature.
9. It is equipped with a walking device to make it movable.
Your message must be between 20-3,000 characters!
